9.5×57mm Mannlicher–Schönauer

Factory loads were manufactured with a 270-grain (17 g) round-nose bullet at from 2,150 ft/s (660 m/s) (from the carbine) to 2,250 ft/s (690 m/s) (from the rifle). This performance ranks the 9.5×57mm on par with or superior to similar medium-bore cartridges such as the 9×56mm Mannlicher–Schoenauer, 9×57mm Mauser, .35 Winchester, .348 Winchester, .358 Winchester and 9.3×57mm. It was superior to the well-established British .375 Flanged Nitro Express, which only developed about 1950 to 2000 fps with the same weight of bullet, and tread closely on the heels of the well-regarded .400/350 Nitro Express and .400/360 Westley Richards cartridges, howbeit these benefitted from a bullet weight of significantly greater sectional density. Since this is normally shot from a 6.5 pounds (2.9 kg) rifle, the recoil is quite vigorous. The recoil energy of 30 ft⋅lbf (41 J) from this combination is about 50% more than an average American .30-06 rifle, but light by the standards of other African game cartridges such as the .375 H&H Magnum.

Ammunition and arms catalogs of the era describe a standard loading of a 270 gr "metal-covered" (i.e., jacketed) soft nose bullet. No other bullet weights or patterns are shown, although it is possible that full-metal-jacketed or other patterns or weights of bullets may have been produced at some time. Curiously, Kynoch lists loads for the 9.5mm Mannlicher–Schoenauer with a 45 grain charge of smokeless propellant (for a muzzle velocity of 2200 fps) and the ".375 Rimless Nitro Express" with a reduced 43 grain charge (for a muzzle velocity of 2100 fps).[4] This may have reflected the differences in the regulation of the sights by the respective manufacturers and distributors, between Westley Richards for the higher powered Mannlicher–Schoenauer loading and the trade rifles with the generic .375 Rimless Nitro Express loading.

Cartridge cases are available from specialist dealers in obsolete cartridges. However, cases are easily reformed from the nearly identical 9.3×57mm, or the 7.92×57mm Mauser, both of which remain in production and continuing popularity in Europe. There are no unusual considerations for handloading this cartridge. Any modern bullet of .375 caliber from 235 to 270 grains will work well, although bullets that intrude deeply into the case may be undesirable due to the relatively small case volume. Heavier bullets of 300 to 350 grains are not advised for hunting because the muzzle velocity will be about 2000 fps or less, which is insufficient to provide normal expansion in most contemporary bullets (which have much thicker jackets than bullets manufactured in the early 20th century).

The cartridge and carbine were primarily made for serious hunting in Africa or India. They were made to be carried over long distances in a hot climate and shot only rarely (the classic "safari"). But when shot, it was usually done quickly, at close range, and at an animal that can maim or kill the shooter. Although the 9.5×57mm MS was considered light for four of the “big five” in Africa (elephant, hippo, cape buffalo, and rhinoceros), it could handle any thin-skinned game including the dangerous ones. It was considered by some African guide-hunters to be an ideal lion gun and cartridge combination in the years just prior to World War I.

Part of the reason the combination was highly regarded was the handling characteristics of the carbine it was chambered in. The carbine was light, well balanced, and had front and rear sights that were ideal for “snap” shooting. The front sight was a “German silver” bead that was visible in almost any light and the 2-position, folding rear sight was a wide spaced “V” (which made it easy to align the sights quickly). There were numerous alternate sights available from the factory and the aftermarket. The power of the cartridge (for stopping dangerous game quickly) was also praised.

Introduced in the 1910 Model rifle, the cartridge was quickly overshadowed performance-wise by the .375 H&H Magnum when it became available two years later (in 1912), albeit the latter was only available in magnum length or specially modified Mauser rifles and therefore remained for some time a more expensive alternative. The 9.5×57mm was still used in Africa into the 1950s.

As with most of the proprietary Mannlicher–Schoenauer cartridges, with the notable exception of the 6.5×54mm MS, the 9.5×57mm MS cartridge has not been produced by anyone other than Kynoch since the beginning of World War II (and only sporadically from them and their successors).

• Mannlicher–Schönauer
• Cartridge (firearms)
• List of rifle cartridges
• 9 mm caliber