Rutan Long-EZ

Aero India, Bangalore (2003)

The Long-EZ was a scaled-up redesign of the VariEze predecessor, allowing for the use of readily available Lycoming aircraft engines in lieu of the Volkswagen-derived engines or hard-to-find small Continentals for which the VariEze was designed. Changes from the VariEze included a larger main wing with modified Eppler 1230 airfoil and less sweep—the canard uses the same GU25-5(11)8 airfoil as the VariEze—larger strakes containing more fuel and baggage storage, and a slightly wider cabin. Plans were offered from 1980 to 1985. As of late 2005, approximately 700 LongEZ's are FAA registered in the United States.

In January 1985, it was announced that plans for a new canard were being offered, to eliminate "rain trim change" that had been experienced by Long-EZ pilots.[4] This trim change is usually a nose down trim change experienced when flying into rain requiring a small aft force on the stick to maintain altitude, which is easily trimmed out, using the bungee trim system. The new canard was designed with the Roncz R1145MS airfoil, which produces considerably more lift than the original GU25-5(11)8 airfoil. This enabled the new canard to be designed with less span, reducing wetted area and thus drag. The new canard has a negligible rain trim, and rain adds only 2 knots to the stall speed.

The aircraft is designed for fuel-efficient long-range flight, with a range of just over 2,000 miles (3,200 km).[5] It can fly for over ten hours and up to 1,600 miles (2,600 km) on 52 gallons (200 liters) of fuel.[6] Equipped with a rear-seat fuel tank, a Long-EZ has flown for 4,800 miles (7,700 kilometers).[7]

The pilot sits in a semi-reclined seat and controls the Long-EZ by means of a side-stick controller situated on the right-hand console. In addition to having an airbrake on the underside, the twin tail's wing-tip rudders can be deflected outwards to act as auxiliary airbrakes.[6]

In 1996 Burt Rutan awarded TERF Inc. the job of publishing the plans for the Long-EZ and other of his aircraft under The Rutan Aircraft Factory CD ROM Encyclopedia for the purpose of further assisting new builders and maintenance for existing builders.[8]

E-Racer

Experimental electric motor power installation

In 1997, Dick Rutan and Mike Melvill flew in convoy around the world in two Rutan Long-EZ aircraft that they had built. This "around the world in 80 nights" flight was called The Spirit of EAA Friendship World Tour, and some legs of it lasted for over 14 hours.[9]

E-Racer

An extensively modified redesign using Long-EZ wings with a fuselage modified for side-by-side seating, retractable landing gear, and larger automotive engine conversion powerplants.[10]

EZ-rocket

XCOR Aerospace modified a Long-EZ and replaced the engine with twin liquid-fueled rocket engines to form a flight test vehicle called the EZ-rocket, which was used as a proof-of-concept demonstrator. Initially, a follow-on version called the "Mark-1 X-Racer, was going to be developed for the Rocket Racing League,[11] but the Velocity SE was subsequently selected as the airframe for the Rocket Racer, rather than the Long-EZ.[12][13]

Twin EZ

Ivan Shaw built a Long-EZ and then converted it into a "Twin-EZ", an aircraft with twin wing-mounted Norton Wankel engines (precursors to the MidWest AE series).[14] Shaw, a Yorkshireman, later designed the Europa XS kitplane.

Long ESA

A 258 hp electric engine conversion. On 19 July 2012, pilot Chip Yates achieved 202.6 mph in level flight, making the aircraft the fastest man carrying electric powered aircraft.[15][16]

Berkez or Berk-EZ

Heavily modified Long-EZ with Berkut 360 components.[17]

Wright Stagger-EZ

Wright Stagger EZ, a three-seat modification of the Rutan LongEZ.

A Steve Wright three-seater design, using standard Long-EZ wings but with a dihedral canard and a rounder, more capacious fuselage. The pilot seat is standard Long-EZ, the co-pilot seat is offset to the right and 13" rearward, and behind the pilot seat is a third seat for a passenger. The co-pilot has a control stick but no rudder pedals. Only one Stagger-EZ was built.[18]

Long-distance EZ (G-WILY)

A standard Long-EZ modified by Bill Allen for long distance, with two wing droptanks for extra luggage and a large additional fuel tank in place of a passenger seat. Bill Allen also installed a Wilksch WAM diesel engine in one Long-EZ that he had built.[19]

Data from Jane's All The World's Aircraft 1982–83[2]

General characteristics

• Crew: 1 Pilot
• Capacity: 1 Passenger
• Length: 16 ft 10 in (5.12 m)
• Wingspan: 26 ft 1 in (7.96 m)
• Height: 7 ft 10 in (2.40 m)
• Wing area: 81.99 sq ft (7.617 m²)
• Empty weight: 710 lb (322 kg)
• Max takeoff weight: 1,325 lb (601 kg)
• Fuel capacity: 52 US Gal (197 L)
• Powerplant: 1 × Lycoming O-235 air-cooled flat-four engine, 115 hp (86 kW)

Performance

• Maximum speed: 185 mph (298 km/h, 161 kn) (max cruise)
• Cruise speed: 144 mph (232 km/h, 125 kn) (40% power)
• Range: 2,010 mi (3,230 km, 1,750 nmi)
• Service ceiling: 27,000 ft (8,200 m)
• Rate of climb: 1,750 ft/min (8.9 m/s)

• On February 28 1990, Wallace Reid Jr. died after his Long-EZ crashed into the sea off Santa Monica after entering heavy fog. [20]

• Singer-songwriter and actor John Denver died when his Long-EZ crashed on October 12, 1997, just off the coast at Pacific Grove, California. The NTSB believes that he inadvertently pushed on his right rudder pedal while twisting to the left in his seat as he struggled to operate the fuel selector valve, which on his aircraft had been moved by a previous owner to a position where it could more easily be reached from the passenger seat.[21] Contributing factors in the Denver crash were other pilot errors, a design that led to an overly optimistic pre-flight fuel-check estimate,[22] a known defective fuel valve that was very hard to turn, and non-standard placement of the fuel selector valve by the kit plane's builder, at variance with Burt Rutan's specifications. Denver was aware of the relocated valve prior to take off and had previously flown the aircraft only for approximately thirty minutes in an orientation flight the day before the accident, although he was an experienced pilot. The NTSB cited Denver's unfamiliarity with the aircraft and his failure to have the aircraft refueled as causal factors in the accident.[21] The aerodynamics of this unusual aircraft did not play a role in Denver's crash.

• On December 20, 1997, the author James Gleick crash-landed his Long-EZ at Greenwood Lake Airport in West Milford, New Jersey.[23] The pilot was on final approach when the engine lost power and landed short of the runway against rising terrain. Probable causes of this accident were deemed to be (i) terrain conditions and (ii) failure of the pilot to use carburetor heat, which resulted in carburetor ice. The pilot was seriously injured and the passenger, his young son was killed.[24]

• On November 17, 2019, Argentine pilot Aldo Nicola died when his Long-EZ (LV-X383) grazed a hangar during low flight and crashed at airfield of General Rodríguez, Argentina. The same pilot and aircraft had been involved in an emergency landing in March 2018.[25]

Related development

• Rutan VariEze

Aircraft of comparable role, configuration, and era

• Berkut 360
• Cirrus VK-30
• Cozy MK IV
• XCOR EZ-Rocket

• Taylor, John W. R. (1982), Jane's All The World's Aircraft 1982–83, London: Jane's Yearbooks, ISBN 0-7106-0748-2

Wikimedia Commons has media related to Rutan Long-EZ.

• Canard aircraft site (ez.org) dedicated to Rutan aircraft
• Wayne Blacklers Long-EZ
• Building and flying a LongEZ
• Hangar Flying » What killed the Long-EZ?