United Airlines Flight 811

United Airlines Flight 811 was a regularly scheduled airline flight from Los Angeles to Sydney, with intermediate stops at Honolulu and Auckland. On February 24, 1989, the Boeing 747-122 serving the flight experienced a cargo door failure in flight shortly after leaving Honolulu. The resulting explosive decompression blew out several rows of seats, resulting in the deaths of nine passengers. It returned to Honolulu, where it landed without further loss of life.

United Airlines Flight 811
N4713U after the cargo door tore off in flight, causing an explosive decompression and ejecting nine people from the plane
Accident
DateFebruary 24, 1989 (1989-02-24)
SummaryCargo door failure due to design flaw leading to explosive decompression[1]
SitePacific Ocean
near Honolulu, Hawaii
20.69°N 158.676°W / 20.69; -158.676
Aircraft
Aircraft typeBoeing 747-122
OperatorUnited Airlines
IATA flight No.UA811
ICAO flight No.UAL811
Call signUNITED 811 HEAVY
RegistrationN4713U (re-registered N4724U after repairs)
Flight originLos Angeles International Airport, Los Angeles, California, U.S.
1st stopoverHonolulu International Airport
Honolulu, Hawaii, U.S.
2nd stopoverAuckland Airport
Auckland, New Zealand
DestinationSydney Airport
Sydney, Australia
Occupants355
Passengers337
Crew18
Fatalities9
Injuries38
Survivors346

Aircraft
N4713U, photographed in 1982 at Los Angeles, seven years before the accident.
The same aircraft in service with Air Dabia, photographed in 1999 at Miami Airport, 10 years after the incident

The aircraft involved was a Boeing 747-122 (registration number N4713U).[2] It was delivered to United Airlines on November 3, 1970.[3] At the time of the accident, the Boeing had accumulated 58,814 total flight hours, 15,028 flight 'pressurization' cycles,[4] and had not been involved in any previous accident.[2]

On February 24, 1989, the aircraft was scheduled by United Airlines to operate as Flight 811 from Los Angeles International Airport in Los Angeles, California to Sydney Airport in Mascot, New South Wales, Australia, with intermediate stops at Honolulu International Airport in Honolulu, Hawaii and Auckland Airport in Auckland, New Zealand.[2]

Flight 811 operated without incident on the first leg of its scheduled flight, from Los Angeles to Honolulu, and there were no difficulties reported by the flight crew upon arriving at Honolulu, where a crew change occurred.[2]

After the accident, the aircraft was repaired and put back into service with United, but was re-registered N4724U. In 1997, the aircraft was taken out of service and passed onto Air Dabia as C5-FBS. Air Dabia ceased operations in 1998, and the aircraft was abandoned at Plattsburgh International Airport, where it was scrapped in 2004.[5][6]

Flight crew

Starting in Honolulu, Flight 811 was helmed by Captain David Cronin, age 59.[1]:101 At the time of the accident, Cronin had logged around 28,000 flight hours, including approximately 1,600 to 1,700 hours in Boeing 747 aircraft.[1]:101 Flight 811 was Cronin's penultimate scheduled flight before his mandatory retirement.[7]

The remaining flight crew consisted of First Officer Gregory Slader, age 48, and Flight Engineer Randal Thomas, age 46, and fifteen flight attendants.[1]:101–103 The first officer and flight engineer had logged 14,500 flight hours and 20,000 flight hours, respectively.[1]:101–102

Accident

Flight 811 took off from Honolulu International Airport at 01:52 local time, with 337 passengers and 18 crew members on board.[1]:1–2

During the climb, the crew made preparations to detour around thunderstorms along the plane's track; the captain anticipated turbulence and kept the passenger seatbelt sign lit.[1]:2 The aircraft had been flying for 17 minutes,[1]:25 as it was passing from 22,000 feet (6,700 m) to 23,000 feet (7,000 m), when the flight crew heard a loud "thump" which shook it.[1]:2 A second and a half later, the forward cargo door blew off. It swung out with such force that it passed its normal stop and slammed into the side of the fuselage, bursting it open. Pressure differentials and aerodynamic forces caused the cabin floor to cave in, and ten seats (G and H of rows 8 through 12) were ejected from the cabin.[1]:8[8] All eight passengers seated in these locations were killed (seats 8G and 12G were unoccupied), as was the passenger in seat 9F.[1]:109[8] A gaping hole was left in the aircraft, through which a flight attendant, Mae Sapolu, in the business-class cabin was almost blown out. Senior flight attendant Laura Brentlinger hung on to the steps leading to the upper deck, and was dangling from them when the decompression occurred. Passengers and crew members saw her clinging to a seat leg and were able to pull her back inside the cabin, although she was severely injured.[8]

The pilots initially believed that a bomb had gone off inside the airliner, as this accident happened just two months after Pan Am Flight 103 was blown up over Lockerbie, Scotland. They began an emergency descent in order to reach an altitude where the air was breathable, while also performing a 180-degree left turn to fly back to Honolulu.[1]:2 The explosion damaged components of the on-board emergency oxygen supply system, as it was primarily located in the forward cargo sidewall area, just aft of the cargo door.[1]:8

The debris ejected from the aircraft during the explosive decompression damaged the Number 3 and 4 engines[1]:4–8 Engine 3 was experiencing heavy vibration, no N1 reading, and a low EGT and EPR, so the crew shut it down.[1]:2 At 02:20, an emergency was declared and the crew began dumping fuel to reduce the aircraft landing weight.[1]:2 The N1 reading of engine number 4 soon fell to almost zero, its EGT reading was high, and it was emitting flames, so they shut it down as well.[1]:2 Some of the explosively ejected debris damaged the right wing's leading edge, dented the horizontal stabilizer on that side, and damaged the vertical stabilizer.[1]:4

During the descent, Captain Cronin ordered Flight Engineer Thomas to tell the flight attendants to prepare for an emergency landing, but he was unable to contact them through the intercom. He asked the captain for permission to go down to find out what was happening, and he agreed. Thomas saw severe damage immediately upon leaving the cockpit; the aircraft skin was peeled off in some areas on the upper deck, revealing the frames and stringers. As he went down to the lower deck, the magnitude of the damage became apparent as he saw the large hole in the side of the cabin. He returned to the cockpit and reported that a large section of the fuselage was open aft of the Number 1 exit door. He concluded that it was probably a bomb and that, considering the damage, it would be unwise to exceed the plane's stall speed by more than a small margin.[8]

As the airliner neared the airport, the landing gear was extended. The flaps could only be partially deployed as a result of damage sustained following the decompression.[1]:3 This necessitated a higher than normal landing speed of around 190–200 knots (350–370 km/h; 220–230 mph).[1]:3 Captain Cronin was able to bring the aircraft to a halt without overrunning the runway.[8] 14 minutes had elapsed since the emergency was declared. All the remaining passengers and flight attendants exited the aircraft in less than 45 seconds. Every flight attendant suffered some injury during the evacuation, ranging from scratches to a dislocated shoulder.[1]:108–109

Despite extensive air and sea searches, no remains of the nine victims lost in flight were found at sea.[1]:4 Multiple small body fragments and pieces of clothing were found in the Number 3 engine, indicating that at least one victim ejected from the fuselage was ingested by the engine, but it was not known whether the fragments were from one or more victims.[9]

Investigation

NTSB initial investigation

The National Transportation Safety Board (NTSB) immediately commenced an investigation into the accident. However, an extensive air and surface search of the ocean had initially failed to locate the aircraft's cargo door.[10]:22 Even though they were not able to inspect the cargo door, the NTSB proceeded with its investigation, and issued its final report on April 16, 1990.[10]:22

The NTSB looked to circumstantial evidence, including prior incidents that involved cargo doors. In 1987, Pan Am Flight 125, another Boeing 747, outbound from London Heathrow Airport, encountered pressurization problems at 20,000 feet (6,100 m), causing the crew to abort the flight and return to the airport.[1]:57[11] After the safe landing, the aircraft's cargo door was found to be ajar by about 1.5 inches (3.8 cm) along its ventral edge. When the aircraft was examined in a maintenance hangar, all of the locking arms were found to be either damaged or entirely sheared off. Boeing initially attributed this to mishandling by ground crew. To test this concern, Boeing instructed 747 operators to shut and lock the cargo door with the external handle, and then activate the door-open switch with the handle still in the locked position. Since the S-2 switch was designed to deactivate the door motors if the handle was locked, nothing should have happened. Some of the airlines reported the door motors did indeed begin running, attempting to force the door open against the locking sectors and causing damage to the mechanism.[8]

Based on the evidence available, and the attribution of prior cargo door malfunctions to damage and ground crew mishandling, the NTSB operated from an assumption that a properly latched and locked 747 cargo door could not open in flight:[10]:37

There are no reasonable means by which the door locking and latching mechanisms could open mechanically in flight from a properly closed and locked position. If the lock sectors were in proper condition, and were properly situated over the closed latch cams, the lock sectors had sufficient strength to prevent the cams from vibrating to the open position during ground operation and flight. However, there are two possible means by which the cargo door could open while in flight. Either, the latching mechanisms were forced open electrically through the lock sectors after the door was secured, or the door was not properly latched and locked before departure. Then the door opened when the pressurization loads reached a point that the latches could not hold.

The NTSB learned that in N4713U's case, the aircraft had experienced intermittent malfunctions of its forward cargo door in the months prior to the accident.[10]:51 Based on this information, the NTSB concluded in its April 1990 report that these malfunctions had damaged the door locking mechanism in a way that caused the door to show a latched and locked indication, without being fully latched and locked.[10]:52 Thus, the NTSB attributed the accident to human error by the ground crew. Based on this hypothesis of in-service damage, the NTSB also faulted the airline for improper maintenance and inspection due to its failure to identify the damaged locking mechanism.[10]:51 Focusing on damage to the door and maintenance procedures, the NTSB concluded that the accident was preventable human error, and not a problem inherent in the design or function of the aircraft's cargo door.

Personal investigation and later developments

Lee Campbell, a New Zealander returning home, was one of the casualties on Flight 811. After his death, his parents Kevin and Susan Campbell investigated the cause using documents obtained from the NTSB.[12] The Campbells' investigation led them to conclude that the cause of the accident was not human error but rather the combination of an electrical problem and an inadequate design of the aircraft's cargo door latching mechanism. They later presented their theory to the safety board.[13]

The Boeing 747 was designed with an outward-hinging door, unlike a plug door which opens inward and jams against its frame as the pressure drops outside, making it impossible to accidentally open at high altitude. The outward-swinging door increases the cargo capacity, but it requires a strong locking mechanism to keep it closed. Deficiencies in the design of wide-body aircraft cargo doors were known since the early 1970s from flaws in the DC-10 cargo door.[14][15] These problems were not fully addressed by the aircraft industry or the NTSB, despite the warnings and deaths from the DC-10 accidents[16] and attempts by Boeing to solve the problems in the 1970s.

The 747's cargo door used a series of electrically operated latch cams into which the door-edge latch pins closed. The cams then rotated into a closed position, holding the door closed. A series of L-shaped arms (called locking sectors) were actuated by the final manual moving of a lever to close the door; these were designed to reinforce the unpowered latch cams and prevent them from rotating into an unlocked position. The locking sectors were made out of aluminum, and they were too thin a gauge to be able to keep the latch cams from moving into the unlocked position against the power of the door motors. Electrical switches cut electrical power to the cargo door when the outer handle was closed; however, if one of those were faulty, the motors could still draw power and rotate the latch cam to the open position. The same event could happen if frayed wires were able to power the cam-motor, even if the circuit power was cut by the safety switch.

As early as 1975, Boeing realized that the aluminum locking sectors were too thin a gauge to be effective and recommended the airlines to add doublers to the locking sectors. After the 1987 Pan Am incident, Boeing issued a Service Bulletin notifying operators to replace the aluminum locking sectors with steel locking sectors, and to carry out various inspections.[10]:22–23 In the United States, the FAA mandated this service by means of an Airworthiness Directive (AD) in July of 1988 and gave U.S. airlines 18 to 24 months to comply with it.[1]:23 After the Flight 811 accident, the FAA shortened the time to 30 days.[8]

NTSB investigation reopened
The cargo door recovered by manned deep sea submersible Sea Cliff.

On September 26 and October 1, 1990, two halves of Flight 811's cargo door were recovered from the Pacific Ocean from 14,100 feet (4,300 m) below the ocean surface. The cargo door had fractured lengthwise across the center. Recovery crews reported that no other debris or evidence of human remains had been discovered.[17] The NTSB inspected the cargo door and determined that the condition of the locking mechanism did not support its original conclusions.[1]:vi

Additionally, in 1991, an incident occurred at New York's John F. Kennedy International Airport involving the malfunction of a United Airlines Boeing 747 cargo door.[18] At the time, United Airlines' maintenance staff were investigating the cause of a circuit breaker trip. In the process of diagnosing the cause, an inadvertent operation of the electric door latch mechanism caused the cargo door to open spontaneously despite being closed. An inspection of the door's electrical wiring discovered insulation breaches, and isolating certain electrical wires allowed the door to operate normally again.[1]:66–68 The lock sectors, latch cams, and latch pins on the door were inspected, and did not show any signs of damage of the type predicted by the NTSB's original hypothesis.[1]:68

Final conclusions

Based on developments after it issued its original report in April 1990, the NTSB issued a superseding accident report on March 18, 1992.[1]:1–2 In this report, the NTSB determined that the probable cause of the accident was the sudden opening of the cargo door, which was attributed to improper wiring and deficiencies in the door's design. It appeared in this case that a short circuit caused an uncommanded rotation of the latch cams, which forced the weak locking sectors to distort and allow the rotation, thus enabling the pressure differential and aerodynamic forces to blow the door off the fuselage; ripping away the hinge fixing structure, the cabin floor, and the side fuselage skin; and causing the explosive decompression.[8]

Outcomes

The NTSB issued a recommendation for all 747-100s in service at the time to replace their cargo door latching mechanisms with new, redesigned locks.[1] A sub-recommendation suggested replacing all outward-opening doors with inward-opening doors, which cannot open in flight due to the pressure differential. No similar accidents leading to loss of life have officially occurred on this aircraft type.

In 1989, the flight crew received the Secretary's Award for Heroism for their actions.[19] The aircraft was repaired, re-registered as N4724U in 1989, and returned to service with United Airlines in 1990. In 1997, the aircraft was registered with Air Dabia as C5-FBS[20] and abandoned in 2001 during overhaul maintenance at Plattsburgh International Airport.[5] In 2004, the aircraft was scrapped for spare parts.

Captain David Cronin died on October 4, 2010, aged 81.[7] First Officer Gregory Slader died September 26, 2016, aged 75.[21]

Passenger John Stephenson would die 25 years later in a separate plane crash. In October 2014, he was killed while captain of a Van's RV-6 light aircraft, when it crashed into a house in the Melbourne suburb Chelsea.

The events of Flight 811 were featured in "Unlocking Disaster", a Season 1 (2003) episode of the Canadian TV series Mayday[8] (called Air Emergency and Air Disasters in the U.S. and Air Crash Investigation in the UK and elsewhere around the world), which included interviews with survivors and a dramatization of the accident. The flight was also included in a Mayday Season 6 (2007) Science of Disaster special titled "Ripped Apart".[12]

See also

References
  1. "Aircraft Accident Report, Explosive Decompression—Loss of Cargo Door in Flight, United Airlines Flight 811, Boeing 747-122, N4713U, Honolulu, Hawaii, February 24, 1989" (PDF). National Transportation Safety Board. March 18, 1992. Retrieved January 14, 2016.
  2. Ranter, Harro (February 24, 1989). "ASN Aircraft accident Boeing 747-122 N4713U Hawaii". Aviation Safety Network >. Retrieved August 16, 2017.
  3. "Air Dabia C5-FBS (Boeing 747 – MSN 19875) (Ex N4713U N4724U ) | Airfleets aviation". www.airfleets.net. Retrieved January 14, 2019.
  4. "02/24/89 United Airlines Official Accident Report" (PDF). Federal Aviation Administration. February 5, 2005. Retrieved January 14, 2019.
  5. "Photo Air Dab".
  6. "Boeing 747 – MSN 19875 – C5-FBS". airfleets.net. Retrieved July 22, 2018.
  7. Gregg K. Kakesako (October 6, 2010). "Hero pilot of United Flight 811 dies at age 81". Honolulu Star-Advertiser. Retrieved January 4, 2015.
  8. "Unlocking Disaster". Mayday. Season 1. Episode 1. 2003. Discovery Channel Canada / National Geographic Channel.
  9. "Nine Sucked Out of Jet 27 Others Hurt As Side of Jumbo Craft Rips Open". The Washington Post. February 25, 1989. Retrieved March 3, 2018.
  10. "Aircraft Accident Report, United Airlines Flight 811, Boeing 747-122, N4713U, Honolulu, Hawaii, February 24, 1989" (PDF). National Transportation Safety Board. April 16, 1990. Retrieved January 14, 2016.
  11. "Precursors". Federal Aviation Administration. U.S. Department of Transportation. Archived from the original on July 14, 2014. Retrieved July 2, 2014.
  12. "Ripped Apart". Mayday. Season 6. Episode 1. 2007. Discovery Channel Canada / National Geographic Channel.
  13. Judith Valente (February 27, 1990). "Roots of Tragedy – Parents Seek Reasons For Death of Son". Wall Street Journal. Retrieved June 24, 2009.
  14. Moira Johnston. "The Last Nine Minutes: The Story of Flight 981". pp. Page 29 Image. Retrieved December 3, 2008.
  15. Moira Johnston (1976). The Last Nine Minutes: The Story of Flight 981. pp. Google Books Search on '747'. ISBN 9780688030841. Retrieved December 3, 2008.
  16. "Archived copy" (PDF). Archived from the original (PDF) on February 25, 2009. Retrieved December 3, 2008.CS1 maint: archived copy as title (link)
  17. "Half of Door From Stricken Jetliner Recovered Off Hawaii". Los Angeles Times. October 3, 1990. Retrieved February 25, 2014.
  18. Kolstad, James L (August 28, 1991). "Safety Recommendation Document A-91-83 and −84" (PDF). et al. Washington, DC, USA: National Transportation Safety Board. Archived (PDF) from the original on October 8, 2012. Retrieved January 26, 2013.
  19. Honoring the Crew of United Airlines Flight 811, House of Representatives, Page H1798, May 10, 1989, Retrieved from the Library of Congress.
  20. "Air Dabia C5-FBS (Boeing 747) (Ex N4713U N4724U )". Airfleets. Retrieved May 18, 2009.
  21. "Gregory Allen Slader". South Whidbey Record. September 26, 2016.
This article is issued from Wikipedia. The text is licensed under Creative Commons - Attribution - Sharealike. Additional terms may apply for the media files.